Building Team - Wednesday

From Susan's blog:

Another day at the work site. Load the bus at 7:30 for breakfast – “same, same” meaning same time, same restaurant, same breakfast. That is one of the few disadvantages of traveling with a large group instead of on my own as there are not that many restaurants that can fit 80 people and get everyone served in 30 mins. Therefore, there is not much variety.

Our job for the day was similar to the first day but more cement pouring then shoveling and grading. The team got 3 squares of cement poured the first day, but it was slow as we were mixing the cement by hand. The Vietnamese would mix the cement on the ground and then we would shovel it in to the wheelbarrows and pour it. We were able to get a cement mixer from somewhere but the town had a power outage for most of the afternoon so we could not get any electricity. We started the day off by laying out the shade sails again to figure out where to put the poles. Before we could pour more cement we needed to know where the poles needed to be placed. The poles are 5 meters high and will be used to tie off the sun shades. Hard to describe, but if all goes well there will be photos to explain in a few days. Funny thing was that they didn’t seem to fit the same way that they had the day before. Odd. So, we moved them around until we found a configuration that we thought would provide shade for the yard and leave an opening for the towers of the playground. Once we had the pole locations identified several team members dug 4-5 foot deep and 2 feet wide holes. That was tough work.

I got put to work building the forms for the cement sections. This involved a lot of measuring, plumb lines and hammers and my tendency to want perfection and precision was appreciated by Dave S who is one of our team leaders. He also strives for the best we can do. We got 2 and a half rows completed. With the cement mixer working today, it was a challenge to keep up the forms with the cement making team. We had a limited amount of material for forms so we would have to wait for a section of concrete to form enough to be able to pull out the used form and put the form in the next section. Besides building forms there was still a lot of digging, weeding and grading the rest of the yard to prepare for cement. Our team put in three of the four poles and angled them so that we would have the proper angle for tension of the shade sails.

Sometime during the day someone was instructed to go buy rope to attach the shade sails. They came back with rope that was about 2 inches in diameter. Humph….something did not translate well on that request. I think asking for strong rope without also clarifying that it needed to be thin rope to fit through the eye holes, was the mistake. So, we knew there would be a few more hardware store runs tomorrow. Of course there is nothing like a Home Depot or Lowe’s here. We have found some small shops that have supplies with the help of the Vietnamese local students.

We finished pouring concrete for two and a half rows of the yard, which is about 1/3 of the yard. We quit at about 4:30 so we would have time to go back to the hotel and shower before dinner. This time I was smarter and took my shoes off before I went in to the hotel so I did not dump sand and dirt all over the hotel room.